05000456/FIN-2012005-07: Difference between revisions

Finding

Title

Licensee-Identified Violation

Description

10 CFR Part 50, Appendix B, Criterion III, Design Control, requires, in part, that design control measures shall be provided for verifying or checking the adequacy of the design. Contrary to the above, from March 28, 2000, to September 13, 2012, the licensees design control measures failed to verify the adequacy of installing thermal relief valves on the MSIV accumulators to address issues associated with pressure-related alarms. Specifically, on September 6, 2012, the licensee identified that the MSIV accumulators could experience a higher temperature than previously considered. Changes in ambient temperatures from a HELB in the area will cause pressure to rise and actuate a small relief valve which bleeds oil back to the MSIV oil reservoir. If too much oil is relieved to the reservoir, there may not be sufficient oil remaining to fully close the MSIV regardless of the accumulator pressure. The licensee performed an operability evaluation and concluded that the thermal relief valves must be isolated to prevent a loss of fluid during these conditions, and instituted a compensatory action that isolated the relief valves. At the time of the exit meeting, the licensee had not determined how compliance would be restored long-term. The licensee entered this issue into their CAP as IR 1409900. This issue was determined to be of very low safety significance (Green) based upon a detailed risk evaluation performed by an NRC SRA.

07
Site:	Braidwood
Report	IR 05000456/2012005 Section 4OA7
Date counted	Dec 31, 2012 (2012Q4)
Type:	NCV: Green
cornerstone	Mitigating Systems
Identified by:	Licensee-identified
Inspection Procedure:
Inspectors (proximate)	M Holmberg M Perry N Feliz Adorno R Ng T Go V Meghani A Garmoe B Bartlett C Moore C Zoia D Szwarc E Duncan J Benjamin J Jandovitz J Laughlin J Robbins
INPO aspect
'
v • d • e

Finding - Braidwood - IR 05000456/2012005

12(1)12(0)12(1)12(1)12(0)12(1)12(1)12(1)12(1)1(0)2(6)3(8)4(6)5(8)7(4)8(2)9(0)12(1)402(0)403(0)404(1)501(0)503(0)9(0)22(0)1(0)15(0)

IR 05000456/2012005: 1 2 3 4 5 6 7 3

Finding List (Braidwood) @ 2012Q4

CCA Matrix: 2012Q4

	Q	CCA	Title
05000456/FIN-2012002-06	2012Q1		Inadequate Safety-Related 4kV Undervoltage Protection
05000456/FIN-2012002-01	2012Q1		Failure to Maintain Approved Fire Protection Program Regarding Safe Shutdown Fire Damper Qualification
05000456/FIN-2012002-02	2012Q1	P.2	Failure to Promptly Correct Conditions Adverse to Quality
05000456/FIN-2012002-03	2012Q1		Failure to Scope Safety-Related HELB Barriers Into the Maintenance Rule
05000456/FIN-2012002-05	2012Q1		Incorrect Classification of Environmental Qualification Zones
05000456/FIN-2012002-04	2012Q1		Maintenance Rule Performance Monitoring of HELB Dampers
05000456/FIN-2012007-03	2012Q2	P.3	Untimely Completion of a Corrective Action to Prevent Recurrence
05000456/FIN-2012007-02	2012Q2	H.8	Surveillance Procedure Not Followed
05000456/FIN-2012007-01	2012Q2	H.14	Non-Conforming Piping Condition Not Corrected
05000456/FIN-2012003-06	2012Q2		MSIV Hydraulic System Design
05000456/FIN-2012007-04	2012Q2	P.5 P.2(a)	Failure to Follow Corrective Action Program Procedure
05000456/FIN-2012003-07	2012Q2		Removal of TRM 3.3.y Requirement Via 10 CFR 50.59 Evaluation
05000456/FIN-2012003-05	2012Q2		Licensees Position Regarding TS 3.6.3 Applicability to Main Steam Isolation Valves
05000456/FIN-2012003-04	2012Q2	H.13	Operability Determination Standards Not Followed for HELB Related Structural Issues Identified by the NRC
05000456/FIN-2012003-03	2012Q2	H.5	Failure to Accomplish Corrective Actions Following Identified Boric Acid Leakage on Reactor Head Penetration No. 77
05000456/FIN-2012003-02	2012Q2	H.14	Steam Generator Primary Manway Bolts Examined with Unqualified Procedure
05000456/FIN-2012003-01	2012Q2	H.1	Failure to Implement Abnormal Operating Procedures When Entry Conditions Were PresentFailure to Implement Abnormal Operating Procedures When Entry Conditions Were Present
05000456/FIN-2012008-02	2012Q3	H.12	Failure to Properly Address Fire Brigade Performance Deficiencies
05000456/FIN-2012008-01	2012Q3	P.2	Failure to Install Foam-Water Sprinklers In Accordance With Sprinkler Standard
05000456/FIN-2012404-01	2012Q3		Security
05000456/FIN-2012004-04	2012Q3	H.9	Failure to Train Fire Brigade Members on the Use of Elevators
05000456/FIN-2012004-05	2012Q3		Failure to Submit a 10 CFR 50.72(b)(3)(v) and a 10 CFR 50.73(a)(2)(v) Report; Inoperable UHS
05000456/FIN-2012004-03	2012Q3	P.3	Failure to Analyze RHUT Inlet Piping Loads
05000456/FIN-2012004-02	2012Q3	H.14	Failure to Adequately Evaluate the Specified TS CST Function After the Identification of a Non-Conforming Condition Adversely Affecting SG PORV Flow Rates
05000456/FIN-2012004-01	2012Q3	P.2	Failure to Adequately Evaluate Operations Crew Performance for a Reactor Trip and Failure to Adequately Evaluate Emergency Operating Procedure Standards
05000456/FIN-2012005-03	2012Q4	H.14	Inadequate Operability Evaluation of Block Walls for High Energy Line Break Loads
05000456/FIN-2012005-04	2012Q4		Operability Evaluation of Block Walls for High Energy Line Break Loads
05000456/FIN-2012005-06	2012Q4		Concerns with the Bases for the Acceptability of GOTHIC for Void Transport Prediction
05000456/FIN-2012005-05	2012Q4	P.5	Inadequate Work Instructions for Ensuring 2A EDG Jacket Water Heat Exchanger Gasket Compression
05000456/FIN-2012005-02	2012Q4		Inadequate PBI Allowance for One EDG DOST Watertight Door Inoperable
05000456/FIN-2012005-01	2012Q4	H.7	Failure to Ensure Watertight Door Safety Function Maintained After Routine Passage
05000456/FIN-2012012-01	2012Q4		Failure to provide complete and accurate decommissioning status reports

Self-Identified List (Braidwood)

	Q	Title
05000456/FIN-2012003-08	2012Q2	Licensee-Identified Violation
05000456/FIN-2012004-06	2012Q3	Licensee-Identified Violation
05000456/FIN-2012005-07	2012Q4	Licensee-Identified Violation

[Braidwood Findings full list]

@@ Line 1: / Line 1: @@
 {{finding
-| title = LICENSEE-IDENTIFIED Violation
+| title = Licensee-Identified Violation
 | docket = 05000456, 05000457
 | inspection report = IR 05000456/2012005

05000456/FIN-2012005-07: Difference between revisions

Latest revision as of 10:46, 30 May 2018

Navigation menu

05000456/FIN-2012005-07: Difference between revisions

Latest revision as of 10:46, 30 May 2018

Navigation menu

Search