ML18045A548

From kanterella
Jump to navigation Jump to search
Physics Testing Rept for Core 4 Startup
ML18045A548
Person / Time
Site: Palisades Entergy icon.png
Issue date: 07/31/1980
From: Kennedy D, Merrick J
CONSUMERS ENERGY CO. (FORMERLY CONSUMERS POWER CO.)
To:
Shared Package
ML18045A547 List:
References
NUDOCS 8008280397
Download: ML18045A548 (25)
v • d • e


Text

{{#Wiki_filter:80 08280 ~'t? PHYSICS TESTING REPORT FOR CORE 4 START-UP July 1980 Prepared By,.,.!) /?(~7 Reviewed By ~O &.*""*/!.

  • 1
1
  • I I

Section 1 Section 2 Section 3 Section 4 Section 5 Section 6 Section 7 Section 8 . Section 9 Section 10 Section 11 Section 12 TABLE OF CONTENTS Introduction ARO HZP Critical Boron Concentration Regulating Rod Bank Worths - No Overlap Regulating Rod Bank Worths In Overlap Sequence Central Rod Integral Worth Calibration Symmetric Rod Worths Moderator Temperature Coefficient ARO and Regulating Banks In Reciprocal Soluble Boron Worth Moderator Temperature Coefficient At Power Power Coef f icfent Power Distribution Conclusion References Page No. 1,2 3 4-8 9,10 11, 12 13,14,14a 15 16 17 18 19,20 21 22

1 SECTION 1 - INTRODUCTION The following report presents the results of the Palisades Plant Core 4 low power and power physics testing. The following procedures were used for this testing: Special Test No Title T-119 Low Power Test Program for Palisades Core 4 T-120 T-121 T-122 T-123 T-124 T-125 T-126 Base Power Level Selection Zero Power Isothermal Temperature Coefficient Measurement Zero Power Rod Worth Measurements Zero Power ARO Critical Boron Concentration Center Rod Worth and Zero Power Symmetry Check Measurement of Moderator Temperature Coefficient At Power Measurement of Power Coefficient The results were obtained from the performance of the above tests, except the power distribution data, which came from the INCA computer routine. Measured results were compared to predicted results (see Reference 1.2) to ascertain whether or not review and acceptance criterion were being violated (see Reference 3). Sections 2 through 11 of this report contain the test results with each section covering a particular test result. The results presented are:

1.

ARO HZP Critical Boron Concentration

2.

Regulating Rod Bank Worths, No Overlap

3.

Regulating Rod Bank Worths in Overlap Sequence

4.

Central Rod Integral Worth Calibration

5.

Symmetric Rod Worths j1 :

6.

Moderator Temperature Coefficient ARO and Regulating Banks In

7.

Reciprocal Soluble Boron Worth

8.

Moderator Temperature Coefficient At Power

9.

Power Coefficient

10.

Power Distribution 2 These results for Core 4 testing differed from Core 3 testing in the following ways: 1) shutdown worth with highest worth rod out (or the N-1 test) was not performed, 2) the highest worth dropped rod was not verified, 3) all symmetrical groups were tested and 4) power testing was done at orie power level, approximately 90%, rather than two. The two tests not performed were not included on the NRC suggested testing list nor in our p~oposed testing schedule, submitted by letter ~ated October 31, 1979, for the Palisades Plant Core 4.

3 SECTION 2 - ARO HZP CRITICAL BORON CONCENTRATION

I I!,,

The all rods out (ARO) hot zero power (HZP) critical boron concentration was measured by obtaining a boron concentration with Group (Gr) 4 rods at almost ARO configuration. The residual worth of Gr 4 was then measured on the reactivity computer and the residual worth was correlated to a change in boron I II I' concentration via the reciprocal boron worth. The boron concentration with Gr 4 at almost ARO configuration was added to the residual worth boron concentration and this result is presented below. Review and acceptance criterion were not exceeded. TABLE 1 Results of ARO HZP Critical Boron Concentration Measured Predicted 1161 ppm 1200 ppm Review Criterion - Measured value within 70 ppm of predicted Acceptance Criterion - None*

SECTION 3 - REGULATING ROD BANK WORTHS - NO OVERLAP The worths of the regulating rod banks were measured by diluting the primary coolant system at*a constant rate, 40 gpm, and trading positive reactivity changes due to dilution with negative reactivity due to rod insertion. The rods were inserted in the manual group mode in the order of Gr 4, 3, 2 and 1. Results are presented in Table 2 of this report. Review and acceptance criteria were not*exceeded. Figures 1 - 4 present graphs of the measured integral rod worths. TABLE 2 Results of Regulating Rod Bank Worths - No Overlap Group Measured %tip Predicted %L'.lp % Deviation %L'.lp Deviation 4 .383 .383 0 0 3 .814 .877 -7.2 -.063 2 .613 .618 -.8 -.005 1 1.447 1.549 -6.6 -.102 4+3+2+1 3.257 3.427 -4.96 Review Criterion - Individual rod banks within 15% or 0.15%L'.lp of predicted value, whichever is greater Acceptance Criterion - Sum of regulating banks within 10% of prediction 4

5 FIG URE 1 ~-.~ ..,....,-,-,T, T'TI::J:===-j

  • --,-...,,-~~~;:e=cp=J;:;=:R=t=tEa~m-i 11.: J
  • __:__j

~ '=:] -.1 I , :, j Lr* i_µ*_t-!* +-~1-:--::1c=...._ .. I ~; 'L. I! +/-~~~f-~f=E£~** ;E!§'§'~~~~~~~~I l;_j*~i_j~!j:;_j~~~EgE§;§'§'i'~L..~:~._ ' ' : ' ' ' I I

  • 1 1

j~--

-f --

I I I l ~ _j I I i I I

_J

~~lljli' 'I ij !ii m*; 1; I 11*11i~

46 0702 J _I

L JT-Ji-111!,-fTTll-,-,,--,--,-,-~-~~

j i I -11*--T:- --1~,, 11*-i-r---.--,----,c-~--r I I -* -~ - -- - -** H--1---l---~- - - ~-*-- --L-- 1-- - -~-.... -* ~- -*.. ~---~~- **- -- __ 1_ - *- -f--- -t--t-HHH--1-~ -t-HH-l-1-- __ --* -* ---1.-- --*r-HHH-l-~---1---1-"'-- -*--* -- --- HH-1-1--1-1--__ _ HH---t-1-- - ------ -- --- 1 -ll-t-t++++f-+--l--l---~=:=l~~;~--~:::--J-I-_~ = =-~--=-':s_~,_.... -'1-;~+_--f+---tl--+---~'--~>----~=-1-::::j_::::J- - - _:::::::1--1-t-rt-+-l--l--:l-!Ll-i-- -** t-t--+++++-l---- - ->---'"**-1--+--1---1-- 1 I-- .* L-1-- -

  • - -t-t---f--1-4--l-
  • ~

+++--1---1--1-- _.__. - -- - - - -- - - -- -*- ---1-- -- ---'--- --1-- --1-- - --H-f-l---1--1- ;-1-t-t-t-t++++-l--l-LC=>t-r-+--4 .*. ~ --- - -* t-t-J-+-l-+-l--P>k-~-LL1--+-1---1---L --- - - -- --- --- - - - - - _:: ~ ::: *::_::_- --- -- -- ----- -- - -+- ->--- - -- 1--. HH--i-+-+--1--1-- 1 - _ _: -~~-=.__ --i--r-r+-+-t-1-'~... J--1--1-L---- -~~ ~~~-=~i-__ -1 -~1---l-HH-*-l-~-4----1-- - - -- -- -~- -t11tttt-t--t--HH-l-l-J~=i:+~~tr-n--l-'.11--j - -- --IN -i--t-+t--H-+-1--l-- - --1-- ~ tttttt-t--t-HHH-f-l-+--l-++=t:-.r:l3:*1j ~i-- -- ---- - --- - I- - tt.tt-llH-t-~-t+++++-1--1-+:::l==!=:ClCl::: n rHH-f-+-+-+-1-- ' rt-t--HH-+---t~-J!~-1--l

  • 1- ~ -

f-* -- I-I- -*._

tilJ-HHH-t-t-+-++++-k+:::~CD ~

~ -- -- 1 1111--f--J-t-t-+++++~-+---l--l-((--I';; *- -- ----- --l-1--l--1--1-- g t--t----HH--1--i--~-l---l-t:l::t:tttt-*i-t-t-t--~-~f-1-t~-i +:::i:::rr-:::'[llHH-t-t-+++++++---i--1-C[-J'. -- -- -*----,_ - -- ~ ~ -1--1--1-.1-~- ~ - -*- - - 1- -i-t--t-f-+-1--~-- - - :-I--- 1-- - '-- - ~ljtJjjjjjtt+++-+-t-t=!=~~=l=t:::t:.itt=ti"'itl ~~;!;~r-~~- 1~--l+----+1---l--~t-=-t.=rti~t=~~~~~1=1=+=+=l=t=t=ll+/-ttffE~RR=t=t=t++++ttttttll---- lo. ----- -- - ---- -- ---- -- - -* *--- -* - -=r-=t:::tttttttt-t-rHHH~~~:::i::::i=++~--;:tj:f+/-j 1 --o~+-1---1--l-r-t-HHl-l---t---[_t_~_t_!"_i*t--i-t-rHH--f--f--J--~-t=!-=!=::l=I _ ~ 1-1--'°::- 1 - ~HHc-l-+-+-~-L-i -- ~ r-1-t---i--f--l-l---1-- t-t---i--1-.. -- -* - - -+-t--1--1--1-- - -!---l---i--l---L--1-- -- --~ *--1--1--1--+-l---l---l-__J__-l-* --- *-~*--- -- 11-r-1H-t--t-l-+-++-l--l--l--lf--J*-_L--~~~.;,.._ __ - - :::_'-l--J~=:;~:::j:::1:::+/-:::+/-=1L. ~ * - :___ -* -- -*- --- ---- - --1-*+++-1--1--1-1-~ -~~ -_:'~ -~~ ~ ~=~

  • -1--,_ --

1--

~- - ---*--- -

--~=~ *--* -*~------------------- +--+-+--1- -- - *- - - -**.. -~----------* -~ - --t--- -~ = =~~===~---1--1-~~:- -f-- --~- - -I-- -*I--- -I-- *- -* -- -r-J--t-HH-1-4--l-- -- ---- I

- I l FIGURE 3 7 \\.. i----**. ~~~~~~:-~~t:~~~~~'""".-:-:*~--n!-:-,_~11-=--~1-,*,-.~---- .. -,-~:::.-.-::--,-~:-.-I:-.~:-,~-. ~-,:- 1 -.l-.. -t:-1:~--:; _: _:_:-l : :~:-r,-r-r,-;::-~*:-;-,--,-i -:,_'_i _____ I* ' I I ' .. ::::~::*_:::*.::::::=-. ;-~--:--~~-----*-"'.--------,-*-{ " :

I

! ! : Ii I

i

---~ I i I

    • - ----*-1----*--:---. ----'---1-----------....:__.- ---,*-"-:---i--,--i. -+_,iH-t--'--'--'---i--l--.i...-'---+---'---+-'-

,-'-1--'-~-+-,:---'---L;* -' ""'!!-ll--~----'--------- ...... _J._; ______, ___. -* - I ' I 1 ... ----~----------'----'----<------'~-_;...----+-:---;-;--j-;-i'-,;,-;-1-'---;--'--;--,------,--+--i--'---+-----+-;'_,__i-+-'-'-'-..... ~C"'l"--;-'----- -1

.. --- :--;*~~--;-.....,.--'----,--+-,----;-~----.,-'--f-::--c_,-+'-+!-'-1-l---'--+++--'-+-+--'--'-+---!--IH--l'-----'-1-+-'-'---.;-+---'- )'-I-_.,;__....,_:__ ____ -'----'-**- __ ;

  • --* *--------1--:-----:-~.-:-,----;-1-,-~--;----:-~-:-,-~--t-,--,---;---r-+-+-'~'-+-1-1-i-,r-:-,--r--'--i ~'---;---:--+-,---'--+--i-1 __,.___,'---;:,~f1-'--'---------j 1 r

! i 1 1,

/:
~~..==::=-=t-'

I I I

~

-1 I i j l I I 1 I I I i ! : f :,/ i ! 1 i i l \\I

7 CJ I
/
    • ***-*--**-**r-----, ---- --,--,--.,.------+--,---,_.,......;-,~.

.,,-1..,--;--,---+--,---,-,-1--,,--;--77.,..;-;.~1-:----:---+-'--+.,....-----.,---1 ____ _:::.::_::::j- -----'."""":*---*--*-t_:__:*-:---:----:-:. --'----'--"'"1*--'-, -'--'---'----l---C-'--'--'--,---' _l'--'---;-l-/-c',,,,.7':'----'-l. _ _,_1!---1-' +' -'!-'-tH-'-'--------- ---=-:-_:=J:==-~-:--=J---* -.--'-:--*--:.. ! I

,./ ~

I -~ I I/, l I i i.. - *----j--'---'-----.l--------'---:--l--~'----+--'--'---:--l~--'---, /~:~--'-4___;_....:...._.:_,__;_+__J_.:..._jf--'---'------ --j I I l I */ J i i CJ ~ ..... --*- ------.. ---r----7--,--,----,--:--,..---t------------;--'-t-:~-+--...,--r-.,---,~-;--..,b"'/'-* -----i--+---'--+-:-i 1 -+;--'---'---:---~h._, ______ - ~- ! I ~----------+-;---;--;--+---'----'--+--'--!--'-!-,..--il-il-i'-':'~'--"'~'-+--,.----,----'---..,_+--'-+---l-!-'-ll-;_;_-+--'-___;_-'-+..;..-iL.;!:--j-!--'--"-'-~-l--~~*-=----L--,_~~~---- I I..!" I i ' : I ! I i i I f I l '

-*---------r-;--;---'------:-------jr--,-:---,---'--:_,,-Jl"-+-+--1-c--;-'---+-+-,.-,-,,....,1-i,l-i,-+,---'----'----i---i--!-'--*-:-+--'----'--'---+-+--l----i-1-+,....;.._--l---'---'-----'-----'---'-r!.---'-;-**---:--

c *. -----------!------'----'-+-'--,_,--:'.,,..,._-"'...,.-'-+-'--'--I---,--:---+--'-+-1+--!--;----'---'-i--;-'-,-' -,--'-+---'-+-+-t:-+*-'--+11-'--1-....;.._'....;.._i --'-~.,..,no<-,,- ___ _;_

+----------+-_,,""7,c;.-__ _..__.._ __

-+----'----'---'-li----'-'-'--'---'---'-----'---'---l--+--i---'-,-+,-!----'---L;-l...1--'---'---'----'---,-~ ... ~--- -~

  • -- **--*---------*r-----------t,-r-:--,-----,----,--+--'--.,---,-------t---'---'-----,--...,.---'---t--'----'---+-;..i __,...; --;-++-'--+--r--'---~..+-'-

----'---------_,,,__.,.9-----------'---+---'--'------'----'---'-~-'---+--'-------;.,-'-, --'---'--+--;--+-'--l--!-l--+-+~,L-;~i-'--I---'-----~

  • --------------,------*-J1./"--+---~-,-----'--+----'-,----:-.,.-+--:--'--'--,-.,.---'---'-+--'---'-+-i--i --';H--:-

1+;, --I--'---'----. i:i..'CL--- ./ T 0

'---:------7'-/'-----l-----'-----'------'-1--------'--'--+~--'--'--L---'-'----'--l----'---'---..!.-.;_L'-L-...L.L.-J-""...::.C*-__:":.;__~

/ I i i I i I .a_t,_ __ /. l i i I ~* *

  • ------------t~<--./-'--:---'-----:--+---'---:--'----'---i-+---'-!-1!--'-+--j--:---i--1...-f--'-'--+--+-+-+--'----'-~'----'-l--'-!'-+!-+'-+-1--+-+---'---l---'---+----'-~'---_j

/. JI i 1 I I! I I ./: j 1 I I I ! I i /

i I

I j I I 1' 'j 1 I I I I I I i I I I I I / Ii l I i i I i I ~ I j I i I I I I i I I I I ' 1 I I

==--.r-"---:----'-+~-+-,'----j'l-i-r-+-+---.-t--+~-t-'~' -+-~'-;'--;-'-;-'-+-+-+-+--;-,'-;'_,-+'-+'--.-+-:---+-',1-;1.......,*_...;-t'---'--+-+-~'*-+;_11-ir-'1-i'-':-+;---:---l--+-'---'-----'----'---j ~-~*--*-*-t";;-~-'------,!-;---1----l' _i_t -:---:-;-': __ 1:_.'i-.-+ 1 1-+--'-1-'--* _:-1:1-ii-'1-~::-+:-+ll-I--+: _,.._' ~:-!'-!:_ 1 _,l--i-:-+;-~+1-+--'-!-!--:: _:___;_-':--':--+::_+-l-'-l--'--'-'-----'----J ,U I 1 i 1 I '~ I I I ! I i I 1 l I

  • --*--~~*~~~r-*-'--'--------c-'--------+---:--:-'--'--'--i--'--+-'--+-,.--+---'-..,.---'---'---t--+--'-----,-,--;---;~-!--'--+------

'--t--'--'--'--'---;--'*_,'--+-'---'--1--'---'---'---'-+--'----'-'--'--'-'---'-"~-+-'--+-'-'-+-'-'L..J-'--+,-'-;-+--"---l----'---~:'--'-,--'----'--~'__,'~-'--'---'-~--~

~-----------11--;-'-'--:--:---+--'---+-------,-~-'-l----'-'-.,.-,----'--+--"--'---'--~'__,_' __ __;_-+-....;..__;__;__'_;.'-+-'--'-!--'-i~---'------ c... --------:---'--+-'---'----i--+---i'-!'-'----+-+--'--'---'---!-llr-'-'-'---i--+-:--'---'-+--;---+---'---+--+--'---l~--,-'--"-l+--i-+--+-i-i-IH'-'----'-l-i---'---I---'---'--------'----'- 1 I I I I j I 1 i i I I : i i i l I 1 \\t>*---------~1--+-~!-lil-i-+-+-:--"'4.....,--r-r~lc--;l-i'-+-'--~l----,--,---:---;----;---~--f'i<t-*;--l'-!l-'--+-+-;---'-~--i--'-'!--.-'---+---11-+-+-+-'--+-~-*~--'-'------1 -~---------'---'-~--f"'-----il-+i-~ 1 ._l--il-ll-+'--+--t-'-+---i--i--l-'-ji-!l---;-;._,..-j-o--'---f--+-i-!l'----+-+-'---,-Ja---'---i-L!'~l!---ll-l--+--!-'~!!---lo.4-4--!--+--t--!---+-+-'-Cl-~--'---L--'---~-!--i ~---*-------.,-,.--1---:-~--'-+l---.-:---;---;-'--;-+-'---;---,--;--;-+'---'-!--+--t---:---+--r--~i---:--'--+-'--'-+~'---;i-+!-+-+-+-L--;--t--+--+-+-+--'-+-+-+--i-i-+'-+-__,___:___;_.c__:_.;--;---j I i I -I ' i I I I I I ! : I I ! I I \\----*---'----:---'--'---f--!-!-!-!-f--"---'-l-+-f--'-'--'-!-!-!i-!-!;--+'-'-'-,-~ll.l\\h0/"""_1~1',~'""-!~"'~~M.,!_Tl-""P~:~""Jli~~l:::>~;~~ITJ.l.,tT~:,--+1--+1-i+--i-i+-+-l-1---iii---1--!-l-l-IJ._+-+-+-IL-'l~i-i_.;.'_;_'_~-'-~ r*-----------r1--:---:--~-*-'...,',_,.---,~-r---'--~_,__~1-1*1_'~-+----**~--'-+--;--'---+--'-+-'-'--'1-1i--;1--;1--+'-+-+-1--+---1--+--+--+--+-+-+--'----'-l---'----'---l--'-----I t~ :::====----------t--:--~-.,--' -':-1~~*--;-'-+-+--'--:--,.---..,.---'---,--+-~+--'--;--11_.1-;l-+-+-+- l,_;-'._;'----':-!-.I-+-:+-+-+-+-+-'--IH-!--+-+-+-l+ 1* -~:--'-' -'1'-'!-'-~---i ,_ *--------------t-----'-l....;...---'--;-+---,-----,----;--+--';--:-'-'--+-+--i---+--11-;-;--'-'+-l-'-!--l--1 -+--+--'--ti-+-1+-+-1-'-I-'-' +-+-+++-+-+-+-+-+-l'-lil-'i-'!-+--,.----1 i ! I I l 1 I !.. --***-- *--- --**---+---~--------+----'----_...._,---'---'~l~-'--~-;--'-__,...I __.__' _:'---'1-f-'-+ i' -+_._-+--+--+--+--'--+-"i_.__,_-+-+--+---1-f-'l-'-1--'-_._-; _i'-'-~-I i* -- I I I I i I 1, i I I I I i i I i r***-- 1 ! , 1 ,, *1 1 1 *i : ! 1 1 1

  • i 1,

,-----*----'--*-.-;~--'---+-1-'-1-'---+--i'---'i-f----',--'--'---'-1-'-,-'----'---L-l--'--'--'-1-+1.....;.__1-!IL..Ji'--'-f-'--'-1-'---'-1'-1'-'-','-+-l--+--+--'--'---11-+-+--+-'-1-+--'--'-,-'.----'---'----'---'---'---1 f-----------1--;--+---cl-tl-+'-t;_,_*_+-lt-~'--;--l...,i,__..-fl-t---;--+-:t-:--+--1,__,1-f-+'_..'-+'--'--+-'~* _,l-;--;'-+'-t-;--+-1+-11--+--+----'l-'-_....__l....__+-+-ll-'--'----'I-'--,---'--'--~ l---*--------'-~-'-1--"-;'-t!-t'-+-ll--;-l-+-+-t--+-~l--;----;-l-;--cl',_,___,_-++-"-~-r---,.--1--;-'-+-+-1~1 -+-~!-+--l+-l,...._,l-t_:..-+1-+-+--~'--t-i!---1iHi-i-l-+__,__l~l'---l-'---'-1*--i--~~:--'-i--~~ L I I i I i I I I I I I

1 i

[ I 1 I i 11 'I I I I I I 1 ***-***--------~+-1--+---1-':--':-t,_.,-+,.-+,-+--+-;-1+--1-1,-;1-+1--;--'-,-+1-+-'----'-_...._-+-_.i_+-1+1.-+-+-1t--1;--,+---;,--+,-~,.-+-+--1l--:,-+-1+--r+---;1-+1-+-11+-+--+-r1-'-'-'___,-'--'--'----'--'--~

) j j FIGURE 4 8 __ ___j ____ --'----7---'-'--'--~-1--,-,_,-'-1_~,.,..-'-1,~r.-+-;;;;;-'-'t:t9'&-~~1._1l!Al'"+-+-+-+--41f-+-+~if-+-+-+--1-+-r1~1-;--+-+-+-+-t---l--r1*-+-_,_;---;-----l1 ___ __L _ _J \\:.01..0::i.. ~.n:£.+ --.llUu I I I I I I ---~~-.~,esf t I I ' I I I I I i i I ! r i i 1 1 1 ! i I I I i I i I I i I I ! -I t i

    • --*----l-----,---~-,.-----:----,-;-----,---~.-:-.--+-,.----:--...,...-+-;1-+1-+--t-:-i-t-t-t---!-t;-+'-+;l-+--+-'--+-l_i,__,_,l-t-r-r-t-;--:--,----+-i~* --1---,-------~-j I

I l 1 i ! -:_::_~:=~1**--:.---,--,,..-,---:-,---+-,---,-.,-,--,--,--,.-.-;1-r-11-+-:11-r-l;1i-+-,'1-+-,li-+-t---;-;--,--'--t-1-:--:-~-+-:--:--, -,~---;--;----,i-+-:--t--~-----,---;

  • -*. -.. :*----t-----,.-~-,---,..---;----+---,----t-,---;-;-rl-;-_._' -;-' _,......,.....,...-,-;-----,---,-~-'--t-t--;-;-;-;-,--,--;-' -+! -:---,--' -*~* --t--->:::

"'~---------!

* -*---***-*----+--'----'--"--'-'-'-'---+-'--'----'--i-+-+--1--'--'l-+'-+-+-+-+-+-+-+-'--+---'--'--'-i_l_.__-'---l--'---'---'--'--'-+--'--1'_.__;__._('11-r----------i

. *-*--* ------*-----+~----,----+---;---;---;---+---'--f---t-!-!t--t-+-+l_,__!-1--t-'t-!-!--t-r-+-'----'---+-'-~l'--'-t-r-1--+-t--_;.._! +' _1,._,,__,~---+-*-----+----'-:----f -* --**.... **-----* _j _-:---:---;--' -:--' -;---'--,-;-----;---;--;--;--;-t-~:---1-r!-t;-t---t-l-t-t-t-t---1-:---:--:-! _,_' -:---+' -*~, -'~-;__,'-ri_,__._-;---+-+-1',_..,lt-1~ 1 l t __J ! I 1 i I I I 1 I i i i ! I I ! i *1 .:_-:__~:- j~-----'----+--+-~-'----__,'-<-ri--+-~l+-l+--11,_,l,_,__,_l--+_._t~! --+---+--,~,~-r--+--_._, --+-l --+--+---~,---*-r------+-------< I I ' I , I* I 1 I i I I I

  • I I

I . =~--~~-=i=.. *-----,--~-;---~;--1-;-_~1* --;--1-..-.-.,.: --+: -;-~,.-;.-,-, --+-~;---;--;--~-:--t--c-:-~-,---.-. r.,_', -,-~----1t--c-------=1 i I i I

I

'i o i I I i I I I l ! i

I I

\\ ! I i j I l j t ' i I I i i l ! i / I rl I ____ -~:*::_-:::_-:_-:__;-:~:_:_..,::::::_~:~:1:;~+,,:_;:;:_;_-_;--_:;::_~;_ 4

_+:::::..;:;;_-~,~-::1_-:1~~1-_:;::1~~/~~~i-~-::;

1_:_; 1_-::~i~_~~~:~:,~-,_:_;~-:_'-_-+--+--+-l+-l+-/~-~1-1~---rS:~-~--~ r* I! i

  • j I

j I i '/: CJ 1""'1, I. I: It I I

/

i j ~ I I I i I i i'

  • i I

I i-----,-~----+---;-~~-+---,---,.--1-t--;1-,;-+-i--t-+;-'-,-+----'--,-+-+-+-+;-:-!-:---+-+~;'--1-+-,1-+1-+;-+!/_,,__! __ -+~i~l-+-fl-+-+-+-+1-+1-+--+----'--~-~"..,.__:---~ i 1 I i ! I I:/ I

  • ---~;

i-------------+------'-----+-r-~!.-+__,__...___,__--'---,-+--'--'---'-+--1_1-;-;-,-+-,--+-'-l-!--!---'-"----'_.-+-'-'-+1__,___,_--+---+-~1,___,i--'-I-'-- 4..1,-..,.----t f ,/

/

j f t

/

---a.* . ------*---- ------+,----------r-----, -.~. _,___;_!-r----'----:-----'----'----+-~~, -I-#----'-----+--~----~~~--- !/*- ~* ~- / 't ~

i-------,-,--'----,.-+---,---,---'---,-+,-.--+--1+--,-,,.--,-,-'--'----;--,---+,~--------;--~l-+-.----,---+-,i--,-'-f!-tl-,-i-;--+--+-,..----_:..;;;.

-*-**---------i-----'---'-----+----'----'-t!-+-'--'---1* -+--'-----.,.--+--'---'-,: "-t--,-;*-t'-+-'--+--' --'-! -+-r--+-~'--+i_.___,_' __,_1 _,__-+-+--;------'-'---i I I I I ,,, ~ I J I

i I

ti! 1 1 I It I i i I l ~ I I I i It I /; t I I I I I I i I / 1 I I I i

i I

i /! ! i i I I ! i I i I I I ! i' ,, I i i i ; i t

'-t---:--;--,,.-;1-+,-t-~1-+-1+--C1-+-+-1-+1-+-+-1

-+--t--,~~1-+-+-+-+-+-i1f-t-+-,1f--t1-+,-1~. ~i-+-1t-i1-+-1f--,1-+1-+-+-+-+-:--t~-.-.,_,r--'__._1-+.-'--:----i 1 I I '/. i I I I I I I I I i I : i ' I I t I I I i I I 1 I I I! I I '~ I I I i 1 I I l i I i I !/I ! I I' I 'I I I 1 I I I .!=----------t---1--+-~---+-~------t-,._Y_I ~i_,_-~l__.l_,__!...,._+-1"---+-+--+-_,......._..-+-~l__,_~:._..1-+--+-+-l..._.l-+--+-+-l,_._.-+...,._-~--+---t l/1 1 i I i

------------1----+--'--,-__._----'-+--,.--~!-,;--;,~-;,.I~l-+l-+-l+--t-r-,~,

-+-i-+-+-+--+-+-~,--+!-+-+-+-41-+-+1-.,-1-+-+-ii-lt-lt----1-'1--t-'-+-+_,__-----,----+----t ~----=--=--=--=--=--=--=--=--=--=---=--=--=--=--=--=--=--=--=--=--::.:-::_-:_,-::_-;:.-::.~-=-'=--=-~-=-~-=-'-'--+-'-,-+,-'-,--+-,1-!-1'--1'-lf-i-+:-+-'--'--+,-'--,-+-'--!---l-41-+-+-+--+1-'-1-'---'--!---l-41-+--!-l+-+-!-ll--'-lt--'---_,___;___;__ __ 4 1 I I I i i l 1 I I i i '1 1 t, I i I I i I i I I ! I I I I 1 I I I I J I ! I I l ~ I ! I I I I i I I I I t I I I

i

! i ' I I i i I t I I I I l ! i t I I I 1 ! I ! t I i I i I I ' i t i i i I I 1 i I I I I ! l I I I i I I t I i t I I I I i I I ' I t I I '--'\\ i I i I i i I ! i I I I I I ! i t ' I I t I I I ! I I I I t ! I I I I I I I I I I i 1 I I ' I I I I i I I I I t i i I ' I ' I I I I I I I ; 1 I I I I I I I I I r--~-_,_-'---'---'--t---'-i--1,'-0,-i-'-+-'--!-+--t--+-i--llf-1-'::d:r.!:~:-+/--'¥-;'~U~::::-f:~~~n-::--:Mf-1,~~.P.=C:,~on~-+/--,1=7 1:1:!:::-Tt-f-l-t-+-ii--ii,r-t-i-i-+-t--+-+--t--+-i--lr--+-+-l-!-ll-ic-'--'--i--i-~i-:-I--'--+-~ 1-----r-'---'--'---l---'--'-l---'-~'-'t-+i-+'---'--+-1-ll1-'1--+l-+_-_,_T-1-ll-1-1-'-'L----l-+l-+-+i-++--+-'-+---'---1-~l-+-1+-.._l1-1--1-L----1-+-+-+-+'--l-1--'---l,___,-'-ti-+l-.._l_i_,_-1 , : I I ! I

I I

I I ' I l I I I

  • -----~------'---+------'--'-'-'-_,_-i--+---'-+--'-;.---!-i-l_.__l--41f-'!--'-1--!--l'-!-+,--'-1-!----+-+-+--'--~1-'-1_,_-+ __ -+--+--'--!--f--i-+-t---+-+--li-+-.,-1-'---.,--'-+---,~~-t i

I I I I I I I I i : I I I 1 1 i I I I I I I I I i i [~~---_**_*_--___ ----,--t---i--'---'-i-+--'---'--'--+-l--,--!-l -:1.-1.i-;--1~-+: _:f-+:-+-+--'-i:f-+-t--+-+--i'-+-+-+-+--ilf-+ 11-+-+--'---' ::'-+- 11-'-+f-if-+-t--'--+-' 1 1..___._:-t---.,..--+- I--;----.,..-----; t 11 i 'I 1 I 11 1 I I I I I I II 1 '_I I 1 I 1 I 1 I I I I --*. _-__ -_-_-_ -----+--'-+--'-'--";-'-,--'-----+-ll'--+:-+-:... 1-1'---l--'1--'-1+-11 +-+--~:--'-:-!--'-+-t--'--1f--i-+--!-:. _,__;* -+---+--t--!--:'--11 -+-+-+-+-. -1,-+l-t--+; -!'-+-+-+-:---,..-'--, -. ;--, -,---1

9 SECTION 4 - REGULATING ROD BANKS WORTH IN OVERLAP SEQUENCE The sequential worth of regulating rod banks was measured by borating* the pri-mary coolant syste'µl at a constant rate, 5 gpm, and trading negative reactivity due to boration with positive reactivity due to withdrawal of the rods. Results are presented in T~ble 3. Figure 5 displays a graph of the measured integral rod worth in sequential _mode. Review and acceptance criteria were not exceeded. TABLE 3 Results of Regulating Rod Bank Worths in Overlap Sequence Measured %.tip Predicted %.tip % Difference 3.24 3.427 -5.46 Review Criterion - None Acceptance Criterion - Sum of regulating banks within 10% of prediction

a.

] RP 1 i p ! il~Lr :<ff~~ef3\\ l~Vhdr~i;~)I i I ____, _ L 1 -f-+ 1 --1-1-1--1. -r-r---1-~' 00 _ 1 l J ~ !---+-+-+----1-.1--1-1--1 1 - _lJ _JU U LLl,-t-+---i-j *1-~:.; L 1u 1 ~ 1111 11 ' I - Li ; : i

*1*

1,. ,1_ .. L. I L ! ! : i : -... -~ *:1 -~-1 j I i I ' I '1 ~- --....,....... - **I. !. I -I i

  • I l.

.. -***- *-. *- I / I f l ! 1 *i ; ... -.... -* "T 1

  • i : I : i

~I >-+-+-+--+-+-1-+-+-+--+-+->-1-+-+---1--1-1-1-+-+---1-+-+---1-+-+-+-+-+---1-+-+-+-+-+-!-+-t-1-1---+-t--+-+-+-<-+-1--+--+-+-<-*-~-1-_,_.,._. __ J. -1.......... _L_ ~, ___ :'"::-~=~--:.-:-

1*

L :l.. l:J j*L ii!.' I... :*.

  • .::------~~-~~:
      • "==--=~--
-l*-ol:*.~'1*-ll:-.!:11_:... 1--

__ *-* _______ 1**. I.... +-1 .. L....

i I i I. -~'" I I I

~\\*. l-+-l-+--+-+ ~-\\ - --~+---t-,_,_.,-+-+-l- ~\\ I _,,. \\ . -\\ i

  • -'*-* J_ I.i... :.

I ' I

~ -: : I

~~~t~~~~~, =~~~:~: -

  • C
= :: J 1, -l+-=

.c: t-l-l--t--+-+-l--l-+-t--+-+-l-i-l--t--t-+-l-ir-t-t--t--!---'~f--t-t--t-+-l-ir-t-t--+-+-+-r-t-+-f-+-+-l--l-+-+-+--t-t----~-*...... -*.......... -t-+-+---1>-+-+--<-+-+-<-+-i---+-+-f-l-+-+---+-+-l--l-+-+--+--+-+-!-+-+---+--+-i-'-+-+-t--+-+-!-+-t--+-~ t: --~-=~ :~=-: ~-- -* ~-- :=*:.: :_: :::::::: __,::::=-:=:-~=-I"',~ -- *- -----f-= =:,_. --r-- -~ - . r-- . *:J~ ~t:,*:t:: :: ~ 0 -e---* - -- - -*-..,_ -* ***- -*--*---- *-~ *--**- -- **** ***- -*-* ** -*-- ---- -~-- *** -* ~ r- ~~ .. ~-- -r- --+--- -------

  • - -.. ~. ***- **- ----1----- -r- -* --+- --.. -*

--~ ~- ~~~~:-~ ~~==- *-*~:= *~ ~ =~ ~~-~~ ~:~:--= -~-- *-... **-f--

  • - *- --. ~:**~ :~ --~ -~ ~~ -~- --*-.

~ =~~=~~ '._:~~==~~~~-= ~ :~:: (:?~~:.~--~--:-~... ::; __ *~---~-:~-~~-~-~--~=.-:_:~_-.** ~ ----**--*-*-*--*-* -*-*f-*---***-*--*--***------*~----*-f-- .~-

  • --1-- *- -

*--1------*-** *-*.

-f--..

... *- -- *- --r-* *- --.. 1-- ---- __.__ ---- - .. ****---~- - .. -* -'-*-----1-- ---* ---~--~---------~-

  • - ***f--*--
  • I-- -* -
    • I--

-. -i--------1----- ------- -i--- - - .. --- -- ---r--* i:: H -- -- ****-* --*f--

--r-* *-1---* ---1-* -- -

.... ~i""\\..

  • -*-.*. --*r--

t--1---

    • f--1*- --

-*~ -- =~~:~=-~--~ -~~~~-,....- -:-=-=~==-~--- --.. -------.- ~-.=--~- : -=:~~~~~ *~ ~~ =: ~~s~ :~=.-::: ___ - .:~-~~~-:- ~--~ -~ ~-:. __ ~ - -- **- .. --*-***-*-1-1-- ____,___ ~:~:~~~=~~~~;;;~~ -".:-=:::=: ::=::~~~:-~ ~ ::: __ ~ -----~ t.~_t_-~~--_**~~---:--~=-: :=~.. :;: _-_; _-. ;~ ~~.. -*. f-t-----***--------*-f--*-------1--***-**-*---------*- ----------1----r-*- I.._ - ****--- -- -*I-- _,___ --*- -- _,_ --.. --f---- ---1--

    • --1--

-* --* -*f-t-f-+-1-- -~ -.. ~~ ~~ ~ ~ ~~ ~~-.... ~'::. __ :~f--=_,_:1~~~;,_-=:f---~~::~_:;;~:~:~:f-____ -.f--~;, __ -_j =_:_ -_. ~-.-~-~~-I~==~*-=~~~~~~* ~ ~ =~ -~ ~ ; _* =~ > ~~ ~~ ~~?. : ~ -- ~.. - 1-t-- - t-- - ~- ...... * ----1--- *-- -- ----*-*i--** -* -* *-~- ~- - 1----1-- --1-- -e-t--+-+........ - . - -*...... - f-t-t--1-+-f- --1---1---**

    • -*------>--~-~---~--

i--- - -**f-1-+---lf-+ i I . 1** I -1 i i

  • ur 0

0 -~- - --~- -*- *-- *- -* - -- --~ -- -*..

  • -*I- -

.r--....,. -*~r--* r--., I -* I - -..,~ I I I I I. I r--t-r* ~/ ' i i I I I i I I I I I I I j 1 1

  • --~

.. -- *- -- f-- - 1)1 0 Gr 3 ----------...,,~, Gr 4 -----------' I )I Gr 2----------~ I)/ 0 I i . I I I .. -1 I i I 3 *. 5 3.0 2.5 2.0

1. 5

.5 0

11 SECTION 5 - CENTRAL ROD INTEGRAL WORTH CALIBRATION The integral worth of the center rod, #35, was determined by diluting the primary coolant system at a constant rate and trading positive reactivity due to dilution with negative reactivity due to control rod insertion: The worth of the center rod is given in Table 4 and a graph of integral worth of the center rod is given in Figure 6. The central rod integral worth calibration had no associated review or acceptance criterion. The purpose of the test was to determine the ratio of measured vs predicted worth which from the results in Table 4 equals 0.698%~p. This ratio was used during the power testing to scale the predicted center rod worth. (Note: The center rod position along with center rod reactivity information supplied in Reference 4 is used to determine the power coefficient and moderator temperature coefficient.) TABLE 4 Control Rod #35 Worth Measured %~p .060 Predicted %~p .0862

11m1 1-n:rT ... -I i* I I !

i. I I
  • I*.
    • 1

>~..... I I ! I 10 x It.\\ *r1...) *1 HE INCH. i :..J HI 11.;1..:1u:s I'\\ t.:UFf-lL ti L~'..-.t.:H CO. MAUl IN ti~. A I 11. Reactivity %!1p I j 46 0702 ' l i ' iJ I i I 1

  • I

. I i I I .. I .. t. i !. I

  • I i I

I. .! l i I i - I. I I I I I i I .. *I I I - ---: ) - J

  • - -r -
1.

- *--* ___ *-.ICL.. -*. I-- -** - ~ - .. ***- --1---- --1-- ---f-.- -*I-- -

        • ... I-

- - -~- - '-- f- -- ----1-- -f-.- -*- - -- -*1--- --*- --*~ -*1---- - --~-1--1-- -- -*

    • -----~*-- -- --*-

-** f*-

  • - **- *- ----1--

.. -- --*I--**- - - -f-1--1--1--1-+-l-4 . *- *-. -- -*-*I-- --~->-~---~-----*-**

****-1------ - ----*-t---

-~* _... !CL._._ ____..._... ..... _ - - -1--1-.1-41--1-1--1 ---... -"- -* 1- - - - -r-

  • -*.. -- -*... ii -- -*-*...

-. ---~- -- ... -.. 11- -.. 1---- - -- - ~- -- -- *-*.. -t-- -*~ - -* -- -- 1-- --- *-*I-- - - -* _,_,__,__,_-L-..._,_, --L-L.. L___ ~ L.. - ~ -* -~ ~-- - =-

=,...~-~: -~~: ~~=.~* ~-:~'=:=: ~[ ::~-=~~~=~=~~=~ :

.... -_......... _**~~:~:~:-=~.:~:-=--~-=-~:~:1:-:.*.. -_._~.*.*.~-=~~.. :* __._-_::_: :=_~_.*. _-__ =-.. ~.=-"_- =~ ~:: <_= ~.~.*'=:_-.. /{_:,_~~~-= =_:_=:= ___,... __ -_-_-=:*-_-~--=~------~I~~~=;=:~

===-=- :.=~*-*-~*-*---* --~~E: ~==~*-r--- ---~~=-~--f_-+_-_1-41--1-1--1--1--1-+-+-l-4--+--+-1-+--+-+-l-J._1 ~ i-.~ ~- ,--'---l--

  • -1---.. -

. *- -* - -- --1-'"'-*<...._.. l--f--l-+-f-4-l--l--l--i--l-*._._:1--J-l--l--i--l--l--.f--f-4-l-l--l--1--11-- -- --. --~- - --* -~,__ - - ~~ -- - -f- ~ I '°lj ---*--1-- -~--~- ---~-~:: -.... l------*--L..._*-* ---.,~- ~ H ~ r ~ g r -l--+-l-+-+-!-~1-1-+-l--f--ll--l-l--l--l--l-+--l--l-4-l--l--l--+--l-* l-f-- - -*. - - -L-'--'--1-.1-.11-.. ~..-i-+++-+--H-1--\\-- r-- --

ti l-11--l-t-f--l-~_-1_-+_-+-._ --. -r--t-+-nr
"'*.-

1.. t:r:1 1-1-+-1--<~--*_,1-1 1-1-1-1--1--1--1---1--1--1--!-41--1-1--1.-1--1-+--1--1--1-1--1--1--1--1--1--i-11-. - ~- -1-11-1-1--1--1-.. r_,111"-HH-l--++++-HH-l--++++-+--HH-l--++++-+--H-4-++-i;;<i-+.,i-.-H..fl.ri --1--~---t--~ - Hl--19- !--l-~l-l-l--1--1--1-+-+-.__ - ~ -~ _.__,_..._,__....... _..._,__, _ _,__,_ -

  • -* -L-

-- *- ~L.. __..___ ~~-l-1-+-l*-1--1--1-*l--l-l--l--l-+-+-l--l~l--+-l--l--l-+-.f-.*l-4-t-l--l--l--l--l--H-l-+--l--I-~ -1_-1--1--!1--l--l-1-+_-1,...-+-_+_: :=-._"-_......._t-_.~,_1-1 1--1->-.. +-11-1--1 *1--1--.f-..l-l--l-.f-..l-l--l-.f-..l-l--l-.f-..l-1--l--.l-1--* ~ =::.: =

  • --lh-.i/.l)--l -l-.+-l-l--+-1-l--l-+-l--l--l-+-l-l--l-ll-l--l-*Hf-+-l-+-f-+-l-+-if-+-l-+-il--+-l-+-if-+-.ii-+-l--+-l

-**.. -+-r--1-1-1--t--t-l--l-f.<;;l-.l-*l--l-l--l-l-+-l--l-l-+--l--l-+-l-+-l-1-+-++-1-+-+-l-l-+-l--l-l-I*-*- - -*'- -- _,_,--t--+-t-t--t--t-+-t-t--i-+-t-t--+-+-1-t--+-+-1-+--+-+-1-+--+-.,_,._,..-+-+-1 r-*l-ll-l-+-l--l--l--l-*l-Hl-l-+*-+-ll:~:JF-+-l-~..._.._._~-1--1--<-1--1--<-+-1--1--.J.--1-+-1--1--1-+-1--<--'-1 1-1-t-l--I- - -.. --* *- ;)"'- --1-'"'-+-1..-1-J.-1-.L- -- - --*I-- --1--l--ll-f-l--1--1--l-+-!--l-l*-+-l--l--l--l-+-+-il--l--l--l--l--l-+-+-Hl--l-l--l [.-' _.__.__ _.__ *-t-*+-1-t-.. 1-1-t-+-+--t-+-*l-t-,r l--l-+--1--1--1-t*- - __ -r- -r-**- -I-- __ --l-....... ~---"l--l--l-+-l-l-l-1--~--+-l--1-+-!--._l-l--l--l--l--l-.f--l-ll--l-l--1--1--.f-.* __ -C ~ _ =: ~-l--l-l--l--1--1--I-*._, ____ - -f-- ________ -* _ ---*t--il--l-1*-l-~-l-+-'!--1--1-t-+-- -; 7 --i.-- - -h -~- l--l-f-l--l--l--l-+-l-l--l-+-*!--1--1-+-!--l--ll--l--l--l--l--l-+-t-*l-l-t-t*-+-l--l-+-+-"l--l-t-l--l--ll-*l-1-l-ll-t-Jl&**l-ll--l-l-.+-+-+-H-4-~+++-+-HH-~-I-- - 1---- - --1-1-1--1--1--1--1--f- - -- --1--1--1--1--1--llal>-1-+-1-+ >-<-+-l--t--1-+-t-<l-+-t-t-- 1--1--l--1-*.... l-l~-l--1--1--1--1-1--1--l-l--I-1--1-+--l--l-l-1--1--1--l--I-+- ~ ~ 1-'-*-~...... _,_.._..._........_, __ """ - - --1--11--1-*-1--1--1--1-'-'-' - -- -* -- - t--l-J.-1--+-*I-l--+--O-+-'-'"l--i-+-t-*-1-+-.1--t-1-.l-+-l-*-i--+-*+-*l-l-* 7 ~ - -*--- -- --- -- --*- --- -- -r-* -----*- -- -- - -- *--1-1-t-l--l-*I-!--- - l--J-+-!--+-1--1--f--j..-j-4-I*- -~ -~ -* *- ~1---i..f--j*~--fl:_~~-.;I_-. =~- ~=-=l-'--i---.f-.--1---1---~-

    • J _.t _ - - - - - - -

-~- ~~ = -~ =-== ~ =*-===--==-~ -----==I~===-~-~*=-~~~: --*1-1->-+_*.-.... _-+-~ ~:. ~ =: --- ---**..

=~==~===~~=~~~~~~=---- *----* --*:~~~~~~~:=~~=~=

I J /! -*. -* - -~--- -* . I' 11"" 1.. 1.o . --v i **r... ; r'~+-+-+-+-1-y :;.-1-I- - I i *1 . yll I 1 11

:::; ~./'l

,i . ~"'. -.*.* *.... *-. - I .. I ! L !.i.T i i I...*..I i l 1.1.L.. J_.L. L... 0 0 0 N 0 w 0 U1 --~- .*... =

  • = :1~ :~~=-==:-

!. I '*t1*-*- ***- r.. : _***1' : :* ~ ] i 1

  • 11

~- ~ ~:.:.= i, I I.

    • ~11 _.__.. ++*1 1*

! *-;*+-'.._1 :.+-t-+-l-1

I ! *1 I ' I I

I I I I I i I i I i I I ! i I: .! ; i I i i i I. I 1 !. i . i ..Li... Li..LL..:.J...!.. ... L 1.

    • - L.

N

13 . SECTION 6 - SYMMETRIC ROD WORTHS The testing of symmetric rods consisted of inserting one rod in a symmetric group while withdrawing a second rod in the same symmetric groupand repeating this sequence for all rods in a symmetric group and all symmetric groups. If the rods in a symmetric group had identical worths, reactivity on the reactivity computer would display the same value following the insertion and removal of any two rods in a symmetric group. Table 5 presents the % deviation of rods in a symmetric group from the group average. This is also displayed in Figure 7 in which a slight tilt is observed. No significant tilt was observed at power (see Section 11). Review and acceptance criterion were not exceeded. TABLE 5 Results of Symmetric Rod Worths Group A Outer Rods Rod No. 1 2 3 4 9 10 lll 12 % Deviation from Group Average -8.14 -1. 74 -1.16 3.49 -1. 74 . 5. 23 -.58 4.65 Group A Inner Rods Rod No. 5 6 7 8 % Deviation from Group Average -3.99 .31 1.84

1. 84

e 14 Group B Rods Rod No. % Deviation from GrouE Average

  • 13

-7.86 14 -3.56 15 -3.26 16 1.66 17

1. 35

'18 5.65 19

1. 35
  • 20 4.73 Group 1 Rods Rod No.

% Deviation from GrouE Average 21 -8.66 22 -3.50 23 -1.80 24 4.20 25 -.51 26 5.90 27

  • 34 28
3. 77 Group 2 Rods Rod No.

% Deviation from GrouE Average 29 -5.38 30 -. 90 31

1. 79 32 4.48 Group 3 Outer Rods Rod No.

% Deviation from GrouE Average 33 -8.42 34 -1.27 36 7.07 37 2.70 Group 4 Rods Rod No. % Deviation. from GrouE Average 38 -6.43 39 .52 40

  • 09 41 5.73 Review Criterion - Each individual rod within 10% of the synnnetric group average Acceptance Criterion - Each individual rod within 20% of the synnnetric group average

FIGURE 7 14a DISTRIBUTION OF % DEVIATION FOR SYMMETRIC ROD WORTHS ~ A-01 1-21 3-33 1-22 A-02* -8.14 -8.66. -8.42 -3.50 -1. 74 A-03 4-38 B-13 P-42 B-14 4-39 A-04 -1.16 -6.43 -7.86 -3.56 .52 . 3. 49 . 1-23 B-15 2-29 A-05 2-30 B-16 1-24 -1.80 -3.26 -5.38 -3.99 -.90 1.66 4.20 3.34 P-43 A-06 3-35 A-07 P-44 3-36 -1.27 .31

1. 84 7.07 1-25 B-17 2-31 A-08 2-32 B-18 1-26

-.51

1. 35
1. 79 1.84 4.48 5.65 5.90 A-09 4-40 B-19 P-45 B-20 4-41 A-10

-1. 74 .09

1. 35 4.73 5.73 5.23 A-11 1-27 3-37 1-28 A-12

+ Rod No. - *. 58

  • 34 2.70
3. 77 4.65

+ % Deviatio n

15 SECTION 7 - MODERATOR TEMPERATURE COEFFICIENT ARO AND REGULATING BANKS IN The moderator temperature coefficient (MTC) was determined at essentially the all rods out configuration and the configuration with the regulating groups in-serted. The MTC was determined by observing reactivity changes on the reactivity computer while cooling or heating the primary coolant system. From the reacti-

  • vity and temperature changes, an isothermal temperature coefficient (ITC) was determined from which the MTC was extracted using the relationship ITC = MTC +

doppler. The doppler coefficient used can be found in Reference 1 and has a value of-1.553 x10-5 6p/°F. The MTC determined for the ARO case was extrapolated to full power using the technique given in Reference 5. Results from the MTC measurements are given in Table 6 and as can be seen, review and acceptance cri-terion were not exceeded. TABLE 6 Results of MTC Measurements Rod Position ARO Reg groups in Measured -6 0 9.39xl0 56p/ F -6.8xl0- 6p/°F Predicted l.4xl0-;6p/°F -7.6xl0- 6p/°F Measured Value Extrapolated to Full Power -5 0 -l.98+lxl0 6p/ F -5. 0 Review Criterion - Measured value within 5xl0 6p/ F of the predicted value. -5 0 -5 0 Acceptance Criterion - Measured value between 5xl0 6p/ F and -35xl0 6p/ F when extrapolated to full power

16 SECTION 8 - RECIPROCAL SOLUBLE BORON WORTH The reciprocal soluble boron worth was determined through the acquisit~on of a boron concentration with the regulating groups inserted and with all rods out (ARO). With these two boro~ end points and the reactivity difference between the end points the reciprocal boron worth is determined. Results of the reciprocal soluble boron worth are given in Table 7~ Review and acceptance criterion were not exceeded. TABLE 7 Reciprocal Soluble Boron Worth Measured 91.7ppm/%6p Predicted 97.2ppm/%6p Difference 5.5ppm/%6p Review Criterion - Within 15ppm/%6p of the_ predicted value. Acceptance Criterion - Less than 125ppm/%6p.

17 SECTION 9 - MODERATOR TEMPERATURE COEFFICIENT AT POWER The moderator temperature coefficient (MTC) at power was determined in a similar manner to that obtained at zero power. The primary coolant system temperature was dropped, keeping core power constant and reactivity changes were obtained by the change in the central rod position (see discussion in Section 5). A -3 0 doppler coefficient of -l.252xl0 %6p/ F was used from Reference 2 to extract the MTC from the isothermal temperature coefficient. Results of MTC measurement at power are given in Table 8. Review and acceptance criteria were not exceeded. TABLE 8 Results of MTC Measurement at Power Measured -5 0 -6.27xl0 6p/ F Predicted Difference -5 0 2.83xl0 6p/ F Review Criterion - Measured value within 5xl0-56p/°F from the predicted value. 1. b 5 10-5 A /°F and -35xl0-5Ap/°F Acceptance Criterion -. Va ue etween x up u when extrapolated to full power.

18 SECTION 10 - POWER COEFFICIENT The power coefficient is obtained by dropping core power and measuring a reacti-vity change from the change in central rod position (see discussion in Section 5). Because of the temperature decalibration of the nuclear drawers, power readings were obtained from the turbine setter. Slight corrections were made to the power coefficient calculated as just described to account for temperature deviations in Tavg and Tref; the predicted power coefficient assumes Tavg equal to Tref. Results from the power coefficient test are given in Table 9. Review and ac-ceptance criteria were not exceeded. TABLE 9 Power Coefficient Results Measured Predicted Difference

1. 96xl0-5 '1p/~

-5 Review Criterion - Measured value within + 3x10 '1p/% power of the pre-dicted value. -5 Acceptance Criterion - Measured value within + 6x10 /1p/% power of the predicted value.

19 SECTION 11 - POWER DISTRIBUTION Information pertaining to the power distribution was obtained from the computer routine INCA which uses incore detector readings to evaluate power distribution parameters. The INCA routine is routinely run and the computer run chosen for this report was one at 92% power and 138.5 MWD/MTU burnup. INCA calculated information or information derived from the INCA results consisted of power distributions, quadrant tilt, assembly power and assembly power RMS deviation. Predicted information used in assembly power and assembly power RMS deviation was obtained from Reference 1. It should be noted that predicted information was at 100% power and 150 MWD/MTU burnup. Acceptance criterion for power dis-tributions based on Technical Specification limits were met. Quadrant Tilt The INCA calculated* quadrant tilt of.16% is well below the review criterion of 3%. Quadrant tilt did not have an acceptance criterion. Assembly Power Predicted assembly power, measured assembly power and percent difference be-tween *the two are given in Figure 8. As can be seen, the criterion listed be-low have not been exceeded. Review Criterion - Measured value within + 10% of prediction if assembly power >9 MWt. - Measured value within + 15% of prediction if assembly power ~~ MWt. Acceptance Criteri.on - None Assembly Power RMS Deviation The assembly power RMS deviation calculated from the assembly powers displayed in Figure 8 equaled 1.82. This number does not exceed the criterion listed below. Review Criterion - RMS deviation is less than 5%. Acceptance Criterion - None

- *- -. _..... *t--* -- -- 1t"1 '\\ 111 *rd T:I[ ll'JO**j1. * *.

  • 11 lf>1**:111:.

to.l'.llf"t"l'L I\\ L~;.. LJ<t t 1>. M.O.lh II* u*..o. -- --.. s.,_ -- - -*- ---.... ] 2b _,. y - -... l.-4 p . *- :_ -Cf2 4*- -- -- - -....:*~-*1*,,11:- *- -* .. -. ~... l.J:IJ.. _ ---- - 1'4~... . I~ Q. -- (ili 3 ........ (*3 8

  • - - -*- -* **-* --~-

--*1- -1--1--1-f-1-- ~- --~- -- *-* -- -** - .. -. 135 __ -_. -* 1 t4l\\... ~.1.1. C7 *-... ' 15~ . -~ 17~. --~ *--- **- *-- *-*- - -l-11-.,- - -* - --1-- -l*-* - -~ - *-* -- - **- ****- oo------- -*-*- --1-,1:

*-**---------**-*t---........ 1------*--*--

---LC... *--*****- -- 1..... _) ____

'~---*

__ L..... ____ ___....J.w~ -* 1-- --- -- -*.** - - ~-= ~- ~ =~ ~~-= ~ ~~= =~ =--=- =~== ~ ~= - ~ ~::~~ ~-- = = ~-:_* -*-------- -~ ~.=~:= 15 2 -~ ~ *-~ ~- ~ -~.=* ~= 8D[~== ~ =-~ ~~9-5-i. ~-: = =* ~ -~ _*:._; _9 9._ 7- *_--_ ~~ -~ =-~..:=:=~ -=~= =~-~-----_-_,_._...._._,_

---- *- -i----*--* -==-===--=== ~~=

-~ ~ ~-:~-~= ~~~-..... - -*-- -=: ~ - ~:_~-E~8 ~= = ~-.~ = ~~-=~-Bi'::.=:==-:=. -~~--~4 B- ~-- =. -~ =---~ -- ~~.g~g: -~~-~-: -=-~=-~==~ *:_ ~~=-=--- *-1 _ _,__._._.__,__._ - -~- --I-- - --i-!-l-f--11--f-J.*- -- !----------------~---- .. -*.__. - -- ---1-+-1--._... _,___ _:.__ - I~... -- -*-I-- --- --* ---*---*-*-----~------***~--;** IT11'-h**- -~... --~-* -... -JCLfl -t! IRM SI 1 'EV h I i I .. --1 i ---~---*-

==:;o~r====~=~9~':

~.o4:>:== ~ ::::*:-= -..~9~:;) ~-

~- -*- - -**... I. l. 812 I I I i I

  • t I I

_L_,_:__UJ.

***f---- ------*-*----------- 1-1-f--I*- -- -* --- -

= :.! 65_ :>: -_: - **--*------- --*-------*----*--- --~:~--:.62:>-=:::_.-

-:_~::::-.-:= =--- -=-=:~-~::::.:: --=-==-==*
~:~1.:. ~ (> :: -

I Ii. i ._:1 1, I I I I I I I I I I I I I ' I I. I I ! i . I I I ; I I i1li/ J1lil :L Iii '1JJI' . l ; I ! I I ! I ; I I I i I L _i_LL __ _L!__~_J_j_L_ i_u_JJ_: _!_ J.. _ I I J ~LI 00 N 0

SECTION 12 - CONCLUSION Low power and power physics testing was conducted at the start of core 4 with the last test finished on June 4, 1980. The testing determined and compared to calculated results various core parameters such as:

1.

Boron Concentration

2.

Rod Worths

3.

Reciprocal Boron Worth

4.

Moderator Temperature.Coefficient

5.

Power Coefficient In all cases, review.and acceptance criterion were not exceeded. 21

REFERENCES

1.

Palisades Cycle 4 Start-up Predictions and Nuclear Data for Operations, XN-NF-79-94, Exxon Nuclear Company, November 1979. 22

2.

Palisades Cycle 4 Reload Fuel Licensing Data Submittal, XN-NF-79-48 Rev 1, Exxon Nuclear Company, September 1979.

3.

Letter from Consumers Power, DPHoffman to Director Nuclear Reactor Regulation, Palisades Plant - Physics Test Program, October 31, 1979.

4.

Letter from ~GGrummer, Exxon Nuclear Company, to BDWebb, Consumers Power entitled Palisades Cycle 4 Start-up Data, Supplementary Information, November 30, 1979.

5.

Palisades Plant Technical Specifications, Section 3.12.}}

Retrieved from "https://kanterella.com/w/index.php?title=ML18045A548&oldid=5025194"